Resource
Technologies
Black
Conductive Releasable Liquid ESD Flooring
Adhesive
MATERIAL
SAFETY DATA SHEET
Chemtrec
24 Hour Emergency Number: 800 424 9300
Distributed By: United ESD
United 24
Hour Technical Support Number: 719 331 0656
HOME
NFPA
Rating: H = 1; R = 0
Section 1: Identity
|
Product Name |
Adhesive 2450 Conductive
Adhesive (black) |
|
Product Code |
CA 2450 |
|
Distributor / Address |
United
ESD.com Inc, 4878 Lakeview Cir, Colorado
City, CO |
|
Manufacturer / Address |
Resource
Technologies, 237 Nance Road NE; Calhoun, GA
|
|
CAS Number |
Proprietary
Mixture |
|
WHMIS Classification |
Not
controlled |
|
Chemical Name |
Proprietary
mixture |
|
Molecular Weight |
Not
applicable - mixture |
|
Chemical Family |
Pressure
sensitive acrylic adhesive with carbon Black |
Note: All components of this product
appear on the inventory of Chemical Substances
published by the U.S. Environmental Protection
Agency (EPA) under the authority of the Toxic
Substances Control Act.
Section 2.
Hazardous Ingredients and Exposure Limits
Components
CAS Number Per cent by weight
TLV Value
None -
"No toxic chemicals subject to
the reporting requirements of Section 313 of Title
III and of 40 CFR are present."
State Regulations: California
Proposition 65
This product does not contain
components listed under the California Safe drinking
Water and toxic Enforcement Act of 1986 (Proposition
65)
Section 3.
Physical and Chemical
Characteristics
| Boiling Point |
212 Degrees
Fahrenheit |
| Specific
Gravity |
1.05 |
| Vapor
Pressure |
Same as water |
| Percent
Volatile by Volume |
50% (water) |
| Vapor Density
(air = 1) |
Same as water |
| Evaporation
Rate (water = 1) |
Same as water |
| Solubility in
water |
Insoluble |
| Appearance
and Odor |
Black viscous
liquid, mild characteristic odor |
| Other |
pH (7.0 -
9.0) |
|
VOC Content |
ZERO calculated, (zero grams / liter) |
Section 4. Fire
and Explosion Hazard Data
| Flash Point |
>212 Degrees
Fahrenheit per Method ASTM D-53 |
| Flammable
limits in air, % by volume |
Lower:
Non-flammable
Upper:
Non-flammable
|
| Extinguishing
Media |
Water, dry
chemical, CO2 |
| Auto-Ignition
Temperature |
Not
determined |
| Unusual fire
and explosion hazards |
None known,
product is non-flammable in aqueous form.
Only dry product will burn. |
Section 5.
Physical Hazards
| Stability |
Stable |
| Incompatible
Materials |
None known |
| Hazardous
Decomposition Products |
None known |
| Hazardous
Polymerization |
Will not
occur |
| Conditions to
Avoid |
None known |
Section 6. Health
hazards (signs and symptoms of exposure: see section
2)
| Threshold
Limit Vale |
Not
determined |
|
Acute Overexposure |
EYE CONTACT:
Avoid eye contact, can cause irritation |
| INHALATION:
No effects are expected |
| SKIN CONTACT:
Prolonged contact can cause skin irritation |
| SWALLOWING:
May cause stomach and intestinal irritation |
| Chronic
Overexposure |
None known |
| Conditions
aggravated by exposure |
None known |
| Toxicity |
No data
available |
| Listed as a
potential carcinogen by: |
|
|
NTP |
No |
|
I.A.R.C |
No |
|
OSHA |
No |
| Emergency
First Aid Procedures |
|
|
Inhalation
|
In case of
overexposure move victim to fresh air. If
breathing is difficult, give oxygen and get
medical attention. |
|
Eye Contact
|
In case of eye
contact flush eyes with water for at least
15 minutes. Seek medical attention is
irritation persists. |
|
Skin Contact |
In case of
contact wash skin with soap and water |
|
Ingestion |
If swallowed
do not induce vomiting. Get medical
attention immediately |
Section 7.
Precautions for Safe Handling and Use.
| Precautions
to be taken in handling and storage |
Store at 40 -
110 Degrees Fahrenheit. Provide adequate
ventilation in the workplace |
| Steps to be
taken if material is released or spilled. |
Cover small
spills using absorbent, then sweep up and
place in waste disposal container. |
| Waste
Disposal Methods |
Dispose of in
accordance with Federal RCRA and applicable
State and Local regulations. |
Section 8. Special
Precautions and Spill / Leak Protection
| Respiratory
Protection |
None required
with adequate ventilation |
| Ventilation |
General
mechanical |
| Gloves |
Impervious.
Neoprene rubber recommended |
| Eye
Protection |
Safety
glasses or splash proof goggles |
| Other |
Keep
containers closed and properly stored.
Maintain an eyewash facility in work area |
|
Transportation |
D.O.T.
Emergency Guide No: Not regulated |
The information and Local laws
and regulations contained herein is based on data
considered accurate. However, it is not to be taken
as a warranty or representation for which the
manufacturer nor distributor assumes legal
responsibility. Any use of this information and
data must be determined by the end user to be in
accordance with applicable Federal, State
Date Prepared:
09/20/2004
Prepared Y. Cunningham